Cruisers Forum
 


Reply
  This discussion is proudly sponsored by:
Please support our sponsors and let them know you heard about their products on Cruisers Forums. Advertise Here
 
Thread Tools Search this Thread Rate Thread Display Modes
Old 02-01-2017, 03:24   #1
Marine Service Provider
 
rcontrera's Avatar

Join Date: Jan 2013
Location: Seattle area
Posts: 58
New scuba compressor for Christmas?

So ... you got a new compressor for Christmas! Congratulations!!

But, before you get too far into playing with the new toy, let's make sure you set it up right.

First off, read your manual (yeah right ... most guys won't until something breaks but I had to say it anyway). Now, do a visual inspection to see if everything looks right ... no lines coming apart, no bent tubing, no obvious defects or damage, etc. If it is an electric motor driven machine, either install the proper plug or have it wired into a box (depends on which motor you have). If you have a fuel driven engine, check the engine oil and fill up with the proper fuel.

Now grab your little adjustable wrench and your bottle of leak detector as well as a rag or paper towel to wipe the oil from the dip stick. Check the compressor oil level and inspect the filter cartridge to make sure it is installed and in good condition. Start the motor/engine for a few seconds to make sure the compressor is turning in the right direction. Once you are sure of the direction, open the fill valve and drain valves and start her up. Air will be flowing out the drain valves and the hose so close the drain valves and the fill valve. Watch as the pressure rises and note where either your pressure switch shuts down or the relief valve lifts and mark it on your log (should be a sample in your manual) ... oh, and shut it down.

Now you are ready to fill so hook up your properly inspected tank, start her up again and watch as it fills. If you have auto drains, note the time between operations. If you have manual drains, crack them open every five to ten minutes for a few seconds until all the moisture is gone. When pressure builds up a bit, spray the connections with your leak detector and make sure everything is tight. If you find a leaker, DO NOT TIGHTEN UNDER PRESSURE ... you could damage the fitting. Mark the offending fitting, shut it down and bleed the system. Then snug up as needed.

Of course, there is a lot more to learn, but this is just a starting primer so you can have fun with your new Christmas toy! Enjoy and take care of her.
__________________
Ray Contreras
CompressorStuff

rcontrera is offline   Reply With Quote
Old 02-01-2017, 03:41   #2
Moderator
 
Pete7's Avatar

Cruisers Forum Supporter

Join Date: Aug 2009
Location: Solent, England
Boat: Moody 31
Posts: 18,423
Images: 22
Re: New scuba compressor for Christmas?

Yep and if its red and made in Italy take it back and buy the little German Bauer one instead.

Pete
Pete7 is offline   Reply With Quote
Old 02-01-2017, 03:46   #3
Marine Service Provider
 
rcontrera's Avatar

Join Date: Jan 2013
Location: Seattle area
Posts: 58
Re: New scuba compressor for Christmas?

This post applies to any color compressor ... including the little Bauer.
__________________
Ray Contreras
CompressorStuff

rcontrera is offline   Reply With Quote
Old 27-01-2017, 11:07   #4
Registered User

Join Date: May 2014
Boat: Shuttleworth Advantage
Posts: 2,246
Images: 2
Re: New scuba compressor for Christmas?

Quote:
Originally Posted by Pete7 View Post
Yep and if its red and made in Italy take it back and buy the little German Bauer one instead.

Pete
Not strictly correct. The little Bauer is a poor choice for use on a boat. The screws are all plated and rust in minutes and they are very susceptible to heal or roll. Coltri on the other hand produce far more blocks for many branded units spec'd for marine use with stainless frames and fittings. Just saying.
Tupaia is offline   Reply With Quote
Old 27-01-2017, 11:15   #5
Registered User
 
Cotemar's Avatar

Community Sponsor

Join Date: Dec 2007
Boat: Mahe 36, Helia 44 Evo, MY 37
Posts: 5,731
Re: New scuba compressor for Christmas?

Do you mean this thing
Attached Thumbnails
Click image for larger version

Name:	Cotemar-13.jpg
Views:	177
Size:	395.2 KB
ID:	140260  
Cotemar is offline   Reply With Quote
Reply

Tags
christmas, compressor, Cuba, scuba

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes Rate This Thread
Rate This Thread:

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
For Sale: NEW Coltri Portable Scuba Dive Compressor - Compact, Stainless Steel capnbob5698 Classifieds Archive 2 12-09-2011 09:15
For Sale: Scuba Compressor - Rix 6cfm oakes Classifieds Archive 0 08-06-2011 07:20
PTO-Driven SCUBA Compressor Dune Auxiliary Equipment & Dinghy 9 02-07-2010 15:20
scuba compressor - what are my options? Sterling Fishing, Recreation & Fun 4 29-08-2008 15:09

Advertise Here


All times are GMT -7. The time now is 07:35.


Google+
Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
Social Knowledge Networks
Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2024, vBulletin Solutions, Inc.

ShowCase vBulletin Plugins by Drive Thru Online, Inc.